Matronics Email Lists :: View topic - Z-12 Architecture

Matronics Email Lists
Web Forum Interface to the Matronics Email Lists

Get Email Distribution Too! FAQ Search Memberlist Usergroups Register

Profile Log in to check your private messages Log in

Z-12 Architecture - Parallel Master Contactors

Matronics Email Lists Forum Index -> AeroElectric-List

View previous topic :: View next topic

Author Message

rckol

Joined: 14 Nov 2008
Posts: 36

Posted: Fri Feb 26, 2010 8:23 pm Post subject: Z-12 Architecture - Parallel Master Contactors

In "A Short Discussion of the Endurance Bus" on page Z-2 of Rev 12A of The AeroElectric Connection it states that "Unless you're planning TWO alternators (Z-12, Z-13 or Z-14) then the purpose of the e-bus is to provide a minimum consumption mode of operation in a battery only condition..."



Z-14 has no ebus



In Z-13, the ebus is tied to the output of the 8 AMP alternator and it functions to limit the load on the alternator (as plan B) but also provides for a battery only mode (Plan C) in the event of an unlikely simultaneous failure of both alternator systems.



In Z-12, it seems the function of the e-bus is a battery only mode of operation for either either of the following:



  a. A Plan B in the event that an open master contactor failure renders both alternators unusable or

  b. A Plan C in the event of an unlikely failure of both alternator systems for other reasons on the same tank of fuel.



For Z-12, if instead of an e-bus, a parallel master contactor was provided:

  a. Plan B in the case of an open master contactor would be to close the parallel contactor resulting in a fully functioning alternator(s) and 

  b.  Plan C would be unchanged.  



The cost and complexity of an extra contactor compared to an e-bus would seem to be about a wash.



What would be the downside other than the need to thoughtfully manage the electrical loads in Plan C?

- The Matronics AeroElectric-List Email Forum -

Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:

http://www.matronics.com/Navigator?AeroElectric-List

_________________
rck

user9253

Joined: 28 Mar 2008
Posts: 1908
Location: Riley TWP Michigan

Posted: Sat Feb 27, 2010 8:55 am Post subject: Re: Z-12 Architecture - Parallel Master Contactors

Re: A second parallel battery contactor in lieu of an E-Bus.



The cost of the E-Bus and diode and switch and relay are relatively inexpensive and weigh less than a second contactor and associated heavy wire.  When I am faced with a decision, I ask myself, "What is best in the long run?" 

   Your proposal is feasible for a backup in case of contactor failure in Z-12 (two alternators).  I do not see any safety issues.  You have double the chance of leaving the master switch on.  

Joe

- The Matronics AeroElectric-List Email Forum -

Use the List Feature Navigator to browse the many List utilities available such as the Email Subscriptions page, Archive Search & Download, 7-Day Browse, Chat, FAQ, Photoshare, and much more:

http://www.matronics.com/Navigator?AeroElectric-List

_________________
Joe Gores

Display posts from previous:

	Matronics Email Lists Forum Index -> AeroElectric-List	All times are GMT - 8 Hours
Page 1 of 1

Jump to:

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum
You cannot attach files in this forum
You can download files in this forum